Effect of Negative Temperatures on the Strength and Deformability of a Reinforced Concrete Element
https://doi.org/10.22227/2949-1622.2023.4.3-12
Abstract
One of the main components of the economic development of the Russian Federation is the current trend in the development of the territories of the Far North and the Arctic. The need for such development is enshrined at the state level in various programs. Experiments on the study of the effect of negative temperatures on the operation of reinforcing steel show that with decreasing temperature, an increase in strength and modulus of elasticity is observed. At the same time, there are no unified recommendations on the deformation and strength properties of reinforcement for calculating reinforced concrete structures under conditions of low and ultra-low negative temperatures. RF standards do not take into account the influence of climatic (up to -70°C) and technological (up to -196°C) negative temperatures on the deformation and strength characteristics of reinforcing steel.
The purpose of this work was to experimentally study the effect of negative temperatures (up to -196°C) on the deformation-strength properties of reinforcement, concrete and reinforced concrete rod elements. Concrete prisms 10x10x40 cm, samples of reinforcement of a periodic profile of class A400 and reinforced concrete prismatic rods with a section size of 12x18 cm and a reinforcement percentage of 1.45% were taken as prototypes. At the same time, the negative temperature of the tests varied. As a result of the studies carried out with centrally stretched reinforced concrete elements, it was found that lowering the temperature to -165°С leads to an in-crease in the cracking force by 162%; strength by 85%. Empirical dependencies are proposed to determine the deformation-strength characteristics of reinforcing steel, depending on the negative temperature.
About the Authors
Andrey D. Istomin
Moscow State University of Civil Engineering (National Research University) (MGSU)
Russian Federation
Russian Federation
Andrey D. Istomin, Candidate of Technical Sciences, Associate Professor, Associate Professor of the Department of Reinforced Concrete and Masonry Structures
26 Yaroslavskoe shosse, Moscow, 129337
Victoria A. Petrova
Smart Construction LLC
Russian Federation
Russian Federation
Victoria A. Petrova, Lead Engineer
5 Nobel Street, (Skolkovo Innovation Center ) Moscow, 121205
References
1. Karpenko N.I., Karpenko S.N., Yarmakovskiy V.N., Erofeev V.T. On modern methods of ensuring the dura-bility of reinforced concrete structures. Academia. Architecture and construction. 2015. No. 1. Pp. 93-103. (In Russ.).
2. Strulev V.M., R.A. Yarkin R.A. On modern methods of ensuring the durability of reinforced concrete struc-tures. Vestnik TSTU. 2003, Volume 9. No. 2. Pp.277-281. (In Russ.).
3. Guzeev E.A., Pinus B.I. Evaluation of the reliability of reinforced concrete structures at low temperatures. Beton i zhelezobeton. 1984. No. 10. Pp. 9-10. (In Russ.).
4. Tamrazyan A.G. Concrete and reinforced concrete: problems and prospects. Industrial and civil construc-tion. 2014. No. 8. Pp. 30-33. (In Russ.).
5. Tamrazian A.G. Methodology for the Analysis and Assessment of the Reliability of the State and Prediction the Service Life of Reinforced Concrete Structures. Reinforced concrete structures. 2023. 1(1). Pp. 5-18. (In Russ.)
6. N. I. Karpenko, V. N. Yarmakovskii, S. N. Karpenko, and D. Z. Kadiev, “On the construction of a diagram method for calculating reinforced concrete rod structures under conditions of low temperatures News of uni-versities. Construction. 2018. No. 6. Pp. 5-17. (In Russ.).
7. Slage G. Work of steel at low temperatures. Cryogenic concrete. Moscow: Stroyizdat, 1986. Pp.106-116. (In Russ.)
8. Pinus B.I., Pinus Zh.N., Khomyakova I.V. Changes in the structural properties of concrete during cooling and freezing. Bulletin of ISTU. 2015. No. 2 (97). Pp. 111-116. (In Russ.).
9. Yarmakovskiy V.N. Strength and deformation characteristics of concrete at negative temperatures. Concrete and reinforced concrete. 1971. No. 10. Pp. 24-25. (In Russ.).
10. Chernykh I.V. Influence of low negative temperatures on the deformation-strength properties of concrete. Problems of development and prospects for the development of the South Yakutsk region. 2001. Pp. 127-130. (In Russ.).
11. Istomin A.D., Alexandrov E.N., Ogurtsova L.P. Influence of the method of water saturation of concrete and negative temperature on its deformation-strength characteristics. Science and technology in the road indus-try. 2018. No. 4. Pp. 40-42. (In Russ.).
12. Elisez M. Prestressed cryogenic concrete. Review of studies conducted in Spain. Cryogenic concrete. Mos-cow: Stroyizdat. 1986. P.114-125. (In Russ.).
13. Mikhailov K.V., Milovanov A.F., Samoylenko V.N. Accounting for the influence of low temperature in the calculation of reinforced concrete isothermal tanks. Cryogenic concrete. Moscow: Stroyizdat. 1986. Pp. 58-63. (In Russ.).
14. Slyshenkov S.O. Cold-resistant reinforcement for reinforced concrete structures. Beton i zhelezobeton. 2007. No. 3. Pp.18-20. (In Russ.).
15. Mulin N.M., Meshkov V.Z. Areas of application of reinforcing steel in structures operated at low tempera-tures. Beton i zhelezobeton. 1977. No. 1. Pp.18-20. (In Russ.).
16. Mulin N.M., Meshkov V.Z. On the mechanical properties of hot-rolled reinforcing steels at low temperatures. Problems of strength. 1970. No. 8. Pp. 18-21.
17. Mulin N.M. Bar reinforcement of reinforced concrete structures. Moscow: Stroyizdat, 1974. 232 p.
18. Kugushin A.A. et al. High-grade reinforcing steel. Moscow: Metallurgy. 272 p.
19. Madatyan S.A. Armature of reinforced concrete structures. Moscow: Voentehlit, 2000. 256 p.
20. Aoyagi Yu., Samoilenko V.N. The work of bending elements under the action of low temperatures // Beton i zhelezobeton. 1982. No. 3. Pp. 19-20.
21. Gorchakov G.I., Guzeev E.A., Seilanov L.A. Combined effect of load and negative temperature on the de-formability of bending elements. Beton i zhelezobeton. 1980. No. 9. Pp. 7-9.
22. Popov V.M., Chernykh I.V. Pinus B.I. Influence of freezing on the bearing capacity of a bent reinforced con-crete element. Actual problems of modern science: Architecture, construction, transport. Samara, 2003. Pp. 56-58.
23. Istomin A.D., Kudryavtsev A.V. Work of statically indeterminate reinforced concrete elements in conditions of negative temperatures. Industrial and civil construction. 2016. No. 7. Pp. 51-55
Review
For citations:
Istomin A.D., Petrova V.A. Effect of Negative Temperatures on the Strength and Deformability of a Reinforced Concrete Element. Reinforced concrete structures. 2023;4(4):3-12. (In Russ.) https://doi.org/10.22227/2949-1622.2023.4.3-12
Views:
403
Email this article 